2007 Volvo VNM
8 Recalls · 100 Complaints · 0 Crashes · 2 Fires
8
Recalls
100
Complaints
2
Fires
No crashes reported
The 2007 Volvo VNM has 8 recalls and 100 owner complaints filed with NHTSA. No crashes have been reported. 2 fires have been reported. The most common issue involves power train:clutch assembly. Compare this to the 2006 Volvo VNM which had 6 recalls.
- Owner complaints have reported 2 fires linked to this vehicle, based on NHTSA data.
Recalls (8)
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch...
Consequence
Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.
Remedy
Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at ...
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
Consequence
IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.
Remedy
VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO...
ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR RPL20 HIGH ANGLE INTERAXLE DRIVESHAFTS, AN IMPROPER SEATED OR MISSING SNAP RING CAN RESULT IN THE BEARING CUP TO SEPARATE FROM THE SLIP YOKE SUB-ASSEMBLY. THE UNIVERSAL JOINT CROSS COULD THEN CONTACT THE SLIP YOKE CASTING AND EVENTUALLY CAUSE THE EAR ...
Consequence
THIS COULD RESULT IN ADDITIONAL DAMAGE TO THE DRIVELINE, THE VEHICLE TO WHICH IT IS ATTACHED AND AY ADDITIONAL NEARBY OBJECTS.
Remedy
DEALERS WILL INSPECT THE DRIVESHAFTS AND REPLACE THEM AS NEEDED. THE RECALL BEGAN ON OCTOBER 23, 2006. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.
Consequence
IF A SHORT CIRCUIT OCCURS AND IS LEFT UNTREATED, COMPONENTS AND WIRING MAY BE SUBJECT TO OVERHEATING WHICH COULD POSSIBLY RESULT IN A VEHICLE FIRE.
Remedy
DEALERS WILL REPLACE THE CIRCUIT BREAKERS WITH FUSES. THE RECALL BEGAN ON FEBRUARY 25, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.
Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VE...
Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Owner Complaints (100)
BOTH front door actuators have failed. Can NOT open the front passenger side door at ALL and the front driver side door will ONLY OPEN from the INSIDE. My passenger had to exit the vehicle through the front passenger side window when the door malfunctioned in January. Then about 2 weeks later we could no longer open the front driver's side door from the outside. The vehicle is available for inspection upon request. My front seat passenger was trapped in the car. Luckily the window was able to roll down and my passenger was limber enough to crawl out through the window.
Over a year ago, my vehicles engine began ticking. On 12/14/2024, while driving the vehicle, it developed a rod knock, went into a limp mode and was towed back to our house. I eventually took the vehicle to Honda in Beaumont, Tx where they did an inspection of the vehicle and verbally told me it was the crankshaft, but would not provide me any documentation stating that. According to the lady at the desk, the service tech had never seen or heard of an issue like this in these vans. I was quoted almost $10,000 to replace the engine with a salvage yard engine with almost as many miles on it. I knew prior to taking it to Honda that there was a recall that did not cover my vehicle regarding this same issue. The vehicle is still parked at my house being started occasionally to keep battery charged.
I was sold this 2024 Mazda cx30 from Ken ganley kia located in mentor Ohio (44060) the vehicle started showing major electrical issues. when they occur I have no control of the functions of anything in the cabin (infotainment, heat/air, braking system,) just to name a few. My wife and I were assured we were purchasing a good safe and reliable used vehicle. I feel this vehicle is extremely unsafe and unpredictable and ken ganley kia of mentor refuse to take this unsafe vehicle back or even pay for the repairs. I am utterly disappointed such a big name in the auto industry could turn there back on a customer not only that let a young family pull off in a unpredictable electrical nightmare of a vehicle and refuse to stand by it.
While driving through west Los Angeles, the vehicle suddenly began emitting white smoke from the engine compartment. There were no prior warning lights, messages, or symptoms indicating a problem. The smoke quickly intensified and turned dark. Thick smoke filled the air, and the cockpit, with the smell of toxic fumes. I safely maneuvered to the shoulder and exited the vehicle with my passenger. Flames erupted from the front of the vehicle. We called 911, which dispatched the fire department. The LAFD responded, cutting open the hood in order to extinguish the fire. The vehicle was towed to a yard following the incident. The vehicle and its contents were declared a total loss. BWM North America dispatched a technician to inspect the vehicle. After inspection, the manufacturer indicated that the starter was the source of the fire. At the time of the incident, the vehicle was subject to a safety recall related to the starter with no remedy available. The failure occurred without warning. Both occupants were exposed to heavy smoke.
we've had to replace the engine. Twice and the electric power steering quit, working completely.And now they want five thousand dollars to replace it.When it's a known problem.
Other Model Years
Related Models
Helpful Guides
Source: NHTSA (National Highway Traffic Safety Administration). Data reflects all recalls and owner complaints on file.